RECALL

[klepto]

2003 COROLLA CE, S, LE

 Year of Recall: 2002
 
  Manufacture: 2002
 
  Manufactured: FROM 20020108 TO 20020213
 
  Component: POWER TRAIN : AXLE ASSEMBLY
 
  Summary:
Vehicle Description: Passenger vehicles. It is possible for the bolts that join the rear brake and hub assembly to the rear axle carrier to be loose due to insufficient tightening during the assembly process.

If the vehicle is operated in this condition, one or more of the four bolts could come loose, causing an abnormal noise from the rear axle area. In the event that all four bolts loosen completely, separation of the rear brake and hub assembly from the rear axle carrier could occur, which could lead to a loss of vehicle control.

Dealers will properly tighten the bolts. Owner notification began March 21, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Toyota at 1-800-331-4331.

[klepto]

Defect Summary:
Vehicle Description: 1998-1999 Toyota sport utility vehicles and light duty trucks equipped with wheel lug nuts, Part No. 1207, supplied by Prime Wheel Corporation, and distributed by Gulf States Toyota, Inc. in the states of Texas, Oklahoma, Arkansas, Louisiana, and Mississippi only. The lug nuts contain a defect which could cause loss of the lug nuts, and possible loss of the wheel.
Consequence Summary:
This condition could cause loss of vehicle control, increasing the risk of a crash.
Corrective Summary:
Dealers will replace all the wheel lug nuts and also perform a complimentary wheel rotation when the repair is done.

[klepto]

HLDI Injury, Collision and Theft Report for Toyota Corolla (FOUR-DOOR CARS)

Collision and theft losses are presented in terms of average loss payments per insured vehicle year. All losses are stated in relative terms, with 100 representing the average injury, collision, or theft loss for all cars (a result of 122 is 22 percent worse that average, 96 is 4 percent better than average,etc.)

All
Vehicle Injury Collision Theft
SMALL  139     111        86
Toyota Corolla
           147      115        97
For further information, visit the HLDI Web site at:
http://www.hldi.org/

[klepto]

Road Tests: First Drive

First Drive: 2003 Toyota Corolla
World Car, Ninth Edition
By Brent Romans
Date Posted 03-26-2002


 Video highlights of this vehicle

Toyota says the Corolla is the world's all-time best-selling passenger car, with more than 25 million units sold in 142 countries. Yes sir, that's a lot of Corollas. Not that we've had much to do with that.

In our 2000 Economy Sedan Comparison Test we ranked the car seventh out of nine cars. We disliked the uncomfortable front seats, tepid styling, high price and soggy handling.

For the 2003 model year, Toyota has introduced an all-new Corolla that addresses many of the car's deficiencies. It's bigger, has more power, is more crisply styled and has higher levels of refinement.

Built utilizing an all-new platform (one that also serves the 2003 Toyota Matrix and Pontiac Vibe), the '03 Corolla is longer, wider and taller. Overall length is now 178.3 inches, as compared to the '02's 174.0 inches. The wheelbase is also correspondingly longer at 102.4 inches.

While this super-sizing boosts curb weight (by about 50 pounds), it does provide more interior room. The big winner is rear legroom. It now measures 35.4 inches, a significant gain of 2.2 inches. Most of the remaining front-and-rear interior dimensions are either about the same, or slightly more. Sitting in back, we noticed the increased legroom immediately. The rear seat is nicely contoured, and two adults should be comfortable, though rear headroom is still less than some of the competition. Trunk space is up from 12.1 cubic feet to 13.6 cubic feet.

For the front passengers, Toyota updated the dashboard and controls for better ergonomics. The audio system is now on top of the center stack, a change from its previously low-mounted location. This was done to make it more accessible, though our initial impression is that it's still hard to reach. Entry and exit is improved thanks to higher-mounted seats, and those seats have additional bolstering for more support. As is typical of Toyota products, the controls and switches have a solid feel to them. The quality of the materials is nothing to get excited about, however, as most of the panels are hard plastic and there's no padding for the driver's armrest.

Of more importance is what you're getting for your money. On this front, the Corolla should certainly satisfy. As before, trim levels continue to be the base CE, the better-equipped LE and the sporty S. More features are standard this year, and even the lowly CE comes with air conditioning with micron filtration and rear floor ducts, a CD player, power steering, power mirrors, an outside temperature gauge, 60/40 split-folding rear seats and 15-inch wheels.

The LE comes with wider tires, variable intermittent windshield wipers, fake wood trim, color-keyed exterior trim, power windows and locks, remote keyless entry, map lights and a driver-seat height adjuster. The S model includes "sporty" trim such as even more color-keyed exterior items, smoked headlights, foglights, special gauges and a leather-wrapped steering wheel. Options include upgraded audio systems, ABS, side airbags, cruise control, leather seating and a sunroof. Compared to similarly equipped '02 models, Toyota says the '03 Corolla is actually less expensive.

In terms of its powertrain, the new Corolla is pretty much a carryover. Under the hood is a 130-horsepower 1.8-liter four-cylinder engine. Thanks to a variable valve timing system (Toyota's VVT-i), this engine provides a broad torque output. It's also clean enough to allow the car to earn ULEV emissions status. Transmission choices are either a five-speed manual or a four-speed automatic. Last year's doggy three-speed automatic has been mercifully removed from the lineup, and fuel economy is rated at 32/40 mpg for the five-speed and 30/38 for the automatic.

On the road, the Corolla makes for comfortable and pleasant transportation. Despite Toyota's hype that the car is more exciting than before, it still offers little inspiration, even in S trim. Acceleration is certainly on par with or better than most other economy cars, and the ride is smooth. For 2003, the rear suspension has been changed to a non-independent torsion-beam design. While perhaps a step back on the technological scale, it's been tuned to a high degree with special shocks and bushings. MacPherson struts are used up front, just as before. Though our drive in the '03 car was brief, this Corolla did seem more stable. The steering is sharper, too, thanks to a relocated steering rack.

While we expect to have a full-road test available soon, our prediction is that the new Corolla will continue to sell to people looking for a safe and dependable economy car. Though the prices are higher than last year, the actual amount of stuff you get for the price is more. And what's wrong with extra stuff?

[klepto]

1999 (1998-2002 generation) Corolla car reviews
There are three Corolla models: CE (cheap), VE (value), LE (luxury). They all have the same engine, but as you move up you get more options built in and more available. There is a value package for each which is free and seems to be included on every car; on the LE, this means a heavy-duty weather package and cruise control.

The Corolla's styling is unobtrusive. It looks small and quiet. With a five-speed transmission, it gets 31 to 38 mpg (our test: 35; should be slightly higher on 2000 and later models due to variable valve timing). So why is it so much fun? I think part of it comes from the lack of acceleration lag; the power is steady from idle to redline, with little if any hesitation (on 2000 and later models, power increased 5 hp, and more torque was available at lower speeds).

On the road, the Corolla is nimble, and tempts you to do things you really shouldn't. Though it tends to wander on the freeway, replacing its standard tires (Goodyear Integrity!) with good ones, such as 195/60 Bridgestone Potenze RE930s, substantially improves handling (especially on wet roads). In fact, a Corolla with very good tires is probably a handling match for a base model Neon, at least in turning - if not in highway stability, where the Neon's excellent suspension shows its acumen.

Corolla LE with touring package  

One area where the Corolla is clearly ahead is in the ease of driving, and the comfort level of driving. There is no tip-in; it's easy to make smooth shifts. Why get an automatic?

It's quiet inside. Not much engine noise comes through; like bumps in the road, it's very muffled. There is wind noise at higher speeds, but on the whole it feels much quieter than its competitors. The ride is a pleasant cross between luxury and sport, which means you can feel the road but you aren't jarred by it.

The headlights are automatic, and it has daytime running lights that use the brights - not a good system. The headlights are powerful and well focused. Interior lighting is also automatic and is logically designed. You can unlock the electric doors from the outside, and whenever you unlock the door the interior lights come on. They go back off again when you start the ignition, after you've stopped the engine, when you shut the door. There is a ring around the ignition switch which lights up when you open the doors. However, the power window lockout oddly prevents the driver from operating any power window but his own.

Trunk space is on par with competitors, but the 70/30 fold-down seats allow you to put in a child seat without losing the fold-down seats. If you can buy one, the built-in child seat also comes with a 70/30 fold-down seat!

Fold-down seat next to fixed child seat - nice if you can get it.  

The radio is substandard. Unlike the Prizm's Delco unit, the Corolla's stereo looks like someone bought it at a local store. The sound is acceptable if not up to the standards of most other cars. The combination tape buttons, presets, and CD controls (even if you don't get a CD player) are confusing and hard to read. After having the car for a while, you will get used to these, even the annoying electronic bass/treble/balance/fade control.
 
The interior seems slightly smaller in back, but roomy enough for most people (people outside the US generally buy cars this size). There are some useful places to store things, though the armrest-compartment is too far back to use while driving, and the cupholders are impractical for most cups and rather flimsy. The coinholder only holds a few coins, which rattle as you drive. The moonroof is set too far back to be seen while driving, but the controls are good. And do you think Toyota could have afforded a lighted glove compartment? Or a hood light? Or instructions on using the jack in the trunk? Or good tires?

Cute black-on-white gauges tend to wash out at sunset  
The trunk is decently sized, and we appreciate the remove seat releases which allow you to push the rear seats forward without much effort. However, access to the spare tire or jack (or whatever tools you store with them) requires the removal of a large cardboard piece, which in turn requires the removal of every single item from the trunk. Chrysler shapes the trunk so a small piece of cardboard sits right over the spare tire area, so that you merely need to move the carpet out of the way, then remove a single small piece of cardboard (which has the tire replacement instruction pasted on the back). Thus, you can leave the trunk half full and still change a tire.

If it seems like we're being critical, it's because this is pretty much the extent of our criticism. We loved this car, from its side airbags to its (impossible to buy without special order) child seat to its nice ride.

Tuned intake helps - they obviously thought about this one.  

That brings us to the next problem. This is lovable car despite its lack of personality. It was a joy to drive back and forth on our 55-mile-each-way commute, and it was also a joy to fill the tank so rarely and so cheaply. The car feels solid and sturdy, and free of noises and rattles. So what's the problem? Price. The Neon is heavily discounted, and Chrysler still makes money off it. You can get a Neon equipped the way our Corolla was for thousands less, with similar build quality.

Is it worth the price? You have to decide for yourself. Toyotas usually do well at resale time. Over the long run, the price difference might be quite small. If you have the money, it's worth driving the Corolla before you buy a Neon.

The Chevrolet Prizm and most US Corollas are built in the GM/Toyota joint venture NUMMI factory in California. It has gone from being a rather poor GM factory to one of the highest-quality facilities you can find, thanks mainly to Toyota's management expertise and the many employee suggestions which were made and implemented. Other Corollas are built in Ontario.

Corolla vs the 2000 Neon
When the Neon came out, it was scrappy and cute, with performance that beat everyone in its price class (including on the race track) and a personality that you either loved or hated. Five years later, in 1999, the Neon had managed to garner a terrible reputation for reliability, thanks to many problems with models built in 1994, troublesome frameless windows, and head gasket failure through late 1997. The second generation addressed these problems, while adding space, comfort, and sophistication. Quality has risen dramatically, and rivals Toyota standards. Now, the two cars are more evenly matched.

Acceleration. In everyday use, we'd say there's an even match. Under hard acceleration the Neon is faster, but generally the Corolla feels the same. The upcoming 150 hp Neon will probably feel faster.
Gas mileage. The Corolla has an edge where gasoline is expensive or people care about pollution. We found the 1999 Corolla to be good for an extra 2 mpg, but the EPA tells us the difference is higher. We bow to their superior testing. The 2000 and later models have better mileage due to variable valve timing.
Handling. Unquestionably superior in the Neon. No loss of traction at all when accelerating from first, even when turning at the same time; no screeching of tires under hard and fast turns. While the Corolla tends to be unstable in windy or high-speed conditions, the Neon is unfazed at all speeds (within its speed limiter) and under high winds. The Corolla also has a hard time with accelerating on turns; the front tires quickly lose grip.
Space. Neon has a much larger trunk, and the pass-through is also larger. The Neon's interior has more space in front and back.
Lighting. The Neon lets you control when the headlights go on, instead of automatically turning them on every time a cloud passes. Both do convenient things with the interior lights when you get in the car or take the key out.
Convenience.
Neon continues its weird front-but-not-rear-power-windows system and awkward HVAC controls.
Corolla has goofy radio controls and no lighting package even on top models.

Neon does not have a standard trunk or gas cap release.
Corolla has more storage compartments, Neon has a very useful change  tray.   Neon automatically locks the doors at 18 mph (with power locks). As with all Chrysler products, the driver's door unlocks when you pull the handle.   Ventilation. The Corolla needs air conditioning even on mild days, but the Neon gets that air flowing nicely. Oddly enough, the Corolla also seems to be the only car sold nowadays without side window de-misters; you have to manually point the vents at the windows to defrost them. Then again, the Corolla is also oddly lacking in such niceties as an underhood and glove box light. The Neon has extremely powerful air conditioning, and the Corolla...doesn't.
Servicing.

The Corolla makes you empty out the entire trunk to get to the spare tire (or the jack, which is very inconvenient to get or replace)...the Neon not only has a convenient center spare with its own cover, but also has instructions printed on the underside of that cover.
Neon trunk - "trunks done right."  

Safety. Both have the second-generation airbags. Corolla can be ordered with side airbags, but there are questions about their usefulness vs. their risk. Both have optional child seats. Good luck finding a Corolla with those!

Quality. Corolla's more reliable than the Neon, but not by an incredible margin. In its class, Corolla remains tops. But Neon's much better than its reputation.

Price. Neon's a bargain until you sell it...would you rather have the money now or later?

Noise. Similar until you get over 60 mph - then the Neon's engine, revving high, starts to make itself known. Generally, the Corolla's engine is quiet and well-mannered, while the Neon's is more raucous.

Overall. The Neon feels sportier and the Corolla feels more refined, though part of that is the sitting position and part is the quieter engine. The Corolla is superior if you want a nice, well-mannered, quiet car and don't mind paying extra for a Toyota. The Neon is superior if you want a sporty car, or better handling, braking, or acceleration, more room, or a considerably lower price tag. Both are far ahead of the other small cars on the market, and neither is a mistake to buy.